I also had the smith put a hole in each of the lids so we could check the liquid level in the kettles with a stick. Some thick leather made a good enough gasket for the lids. Sandbags held them down tight and wooden plugs took care of the holes in the lids.
By midafternoon, we had a still that any moonshiner would be proud of.
With the help of one of the cooks, I put forty gallons of bad beer in the boiler kettle and got a fire going under it. We filled the washtub around the condenser kettle with cool water and sat back to watch it work. By dark the level in the boiler had gone down about ten percent and I figured that we’d gotten all that we were going to get.
Sure enough, there were about four gallons of clear liquid in the bottom of the condenser. I took a pitcher of it into the inn and told the cook to put the rest into a barrel someplace. What was left in the boiler could be fed to the pigs.
Tadeusz was eagerly awaiting the results of our efforts. The thought of a new drink fascinated him.
You see, there were very few things to drink in the Middle Ages. There was wine that had to be imported. There was beer that was flat for lack of any container that could hold pressure. There was water that often wasn’t safe to drink. There was milk that was only available in the spring and summer. And that was all. Nothing else existed with which a person could quench his thirst.
He looked with great anticipation at the pitcher in my hand, and broke out his two best (and only) glass goblets. Glass was rare and fabulously expensive. They were the only bits of glass at the inn, reserved for the bride and groom at wedding feasts. The other guests at the head table had to make do with silver.
I poured two fingers worth into each glass and we drank.
It was raw and rough and rugged. Wicked stuff. I once tried the product of an Appalachian moonshiner and while my results weren’t quite as bad as his, I came close.
Tadeusz was literally cross-eyed. I’d heard of people having that reaction, but I'd never seen anyone actually do it before. There were beads of sweat on his forehead and his breathing had stopped. I had to pat him on the back to get it going again.
Once he was something like normal again, he wheezed, “Sir Conrad. Do your people actually drink that?”
“Well, something like it. I think it needs aging.”
“God in heaven, but yours must be a tough people.”
“Not really,” I said. I held the lip of my goblet to the lamp on the table. The dregs burned vigorously and that meant that it was over fifty percent alcohol.
Tadeusz stared aghast at the burning drink, shook his head and walked away.
It took the cook over a month to process the entire six thousand gallons of bad beer. In the end, we had six hundred gallons of white lightning (I couldn’t in justice call this stuff whiskey), which was stored in oak barrels in the inn's basement. On rare occasions, some adventurous buck would ask for a mug of it, but I don't think anybody asked twice. I kept a bottle for use as an antiseptic for my medical kit.
Part of my deal with my liege lord Count Lambert was that I was to return to Okoitz once a month to oversee the construction we had going on there. The first month was up and I had to go.
The problem was that the girls naturally wanted to go along and pay a visit to their families and friends. The count had given me the girls, and probably my lands as well, because they had started imitating the manners of the nobility rather than acting like dumb peasants. He ’felt that it was all my fault and maybe it was.
But he wanted them out of Okoitz before everybody started acting uppity. To bring the girls back would not have been wise. But the girls didn’t know that they had been thrown out of their home and I didn't have the heart to tell them.
To make matters worse, Sir Vladimir insisted on coming with me. I had no right to tell him what he could do or not do, and I didn’t want to offend the guy. I liked him and I could see where he could be very useful in the future.
Finally, Sir Gregor came to my rescue by suggesting that he and his brothers take the girls on a hunt on my new land before I “ruined” it with a lot of buildings. It only took an hour to talk the girls into it. I mean, I might be the girls’ protector, but I wasn't their chaperon. They knew the score. It wasn't as if they were virgins.
FROM THE AUTOBIOGRAPHY OF SIR VLADIMIR CHARNETSKI
Sir Conrad and I arrived at Okoitz to find Vitold, Count Lambert’s carpenter, installing the sails on the windmill that was being constructed in the bailey.
This windmill was a huge affair and the top of the turret was higher than the roof of the church. The blades went much higher and the topmost of the twelve was so tall that I think one could stack ten peasant huts one above another and not reach the height of it.
The windmill was surrounded by a circular workshed and it was on the roof of this that the carpenter worked. Count Lambert and six of his knights were also on the roof watching. Perforce, we climbed up to join them.
“Greetings, Sir Conrad,” Count Lambert said. “I see that you have brought the excellent Sir Vladimir with you. You see? It’s nearly done.”
“There’s been more progress that I had expected, my lord,” Sir Conrad said.
“My people have worked at little else since they finished spring planting. I’ll wager that you think better of them now than you did at the Christmas party.”
“No bet, my lord. Not on that subject anyway.”
“Yes, there is our wager as to whether or not this mill will work, isn’t there? Twenty-three thousand pence, wasn't it? It seems you're gaining on me.”
“We’ll know soon, my lord. The mill looks about done,” Sir Conrad said.
“Only on the outside, my lords,” Vitold said. “I don’t have the pumps and cams all hooked up yet inside and she's got to be way out of balance.”
The last of the sails was on and the great wheel started turning slowly in the breeze.
“You haven’t painted the sails with linseed oil the way you were supposed to,” Sir Conrad said. “The sails will draw much better if they're not porous.”
“We’ve ordered some linseed oil out of Wroclaw, Sir Conrad, but it hasn't come yet. I just wanted to see how the axle shaft turned before I got to work on the pumps.”
“Then I guess you’ve learned what you wanted to know. It seems to turn easily enough. Like you said, the balance is way off, but you'll have to wait until the pumps are on before you can work on that. Also, I think that the set of the sails could be improved, but that's the last thing you'll want to play with. I guess you can stop it now.”
“Now that’s something I wanted to talk to you about, Sir Conrad. I understand how to make it go, but you never said anything about how to make it stop.”
“What? To stop it?” Count Lambert said. “There’s naught to that! Watch!”
I fear that my Count Lambert had scant experience with the vast power of that huge wheel. He put his arm around the next blade as it came slowly by and attempted to bring it to a halt. The vast wheel heeded his efforts not at all, but continued around.
The count, unused to any disobedience, clung on and was soon swept off the roof of the shed.
Still clutching the windmill blade as it began to rise, he shouted, “You men! Help! Attend me!”
Sir Bodan said, “Right, my lord!” and grabbed onto the next blade as it went by.
Sir Stefan took the blade after and what was I to do? My father’s liege lord had bid my attendance in time of his peril. And peril it was indeed, for Count Lambert had now risen halfway to the top and was as high as the church roof with naught but air between him and the ground. Could I show the white feather at such a time.?
For the honor of my family, I grabbed the next blade.
With a force that could not have been matched by a team of eight oxen, the great blade lifted me off the roof. I soon found that I could stand on the ropes that held the bottom of the sails and so for a short while was not greatly discomfited.
The other four knights followed thos
e already on the wheel, leaving only Sir Conrad and Vitold on the roof of the shed. By this time, I had risen more than halfway up and my head was lower than my feet. Count Lambert was at the top, completely upside down, saving his life by clutching the blade with arms and legs. I imitated his posture.
Perhaps due to the weight of the men on one side, the wheel was slowing noticeably. As luck would have it, it stopped just when I was hanging upside down at the top.
I did not like it.
I could hear and see everything with that crystal clarity which comes with great danger. Far below, I could hear Sir Conrad and Vitold talking.
“The sails were supposed to be held on with slip knots, like you use on shoelaces,” Sir Conrad said. “Then you could stop the mill by pulling the cords as the blades went by.”
“I must’ve missed that part. We didn't use no slip knots,” Vitold replied. “I know! We can cut the ropes!”
“It’s a little late for that. We have to get these men down. It would probably be best to push it all the way around. That will get Count Lambert off quickest. Get those men up here on the roof.”
The whole population of Okoitz had gathered to watch the first turning of the mill, and I heard them shouting to us. Some were praying to God in heaven for our deliverance and some offered bad advice as what would be the best thing to do. No few of them were making wagers on which of us would fall first. The odds of my survival were the lowest of the lot.
But they were all on the ground and it took some time to get them on the roof.
Time was just what I could not spare, for my case was worse than that of the other knights. Not only was I the most vertically oriented, but they were dressed in ordinary clothes where I was just in from the trail and was perforce still in chain mail.
My helmet slipped from my head and fell for a horribly long time before bouncing off the roof of the shed, narrowly missing Sir Conrad. I’d almost killed the man I'd sworn to protect.
Worse, the blade I was clutching was of fresh pine and smoothly planed. I began slipping downward, head first. Count Lambert saw me and called to me to hold tight, but I was already holding with all my might and there was nothing more that I could do to obey him. I continued downward.
At first this frightened me, but I soon reasoned that down was precisely the direction that I wanted to go, could I but do it slowly enough.
Eventually reaching the hub of the wheel, I was able, with considerable difficulty, to remove myself from the blade and stand on the axle.
I was still a great distance in the air, but at least I was now upright and had something beneath my feet. I paused a moment to catch my breath.
By then, Sir Conrad had fifty peasants on the roof and together they were able to turn the stalled wheel. But the first motion took me unawares and I started to fall from the huge axle.
I saved myself by grabbing on to another blade of the wheel, this time to the one Sir Lestko was on. He was the last man in line, so perforce I was carried again higher, but now with my feet toward the hub.
They turned the wheel sufficiently for Count Lambert to step off, but by this time the force of the wind and the weight of the men was such that the wheel again turned of its own accord. The other knights were able to remove themselves without difficulty as they each came to the bottom, but I was halfway between rim and hub and thus continued around.
Sir Conrad saw my predicament.
“You must slide toward the rim!” he shouted. “If I cut loose the sails now, there’s no telling where it will stop. You might end up on top again. Slide down when you are on the bottom half of the cycle and hold tight when you're at the top!”
I could see the wisdom of his suggestion, but the doing of it was no small task. In all, I went around nine times before Sir Conrad and Count Lambert could pick my weary body off the wheel and set me upright.
“Sir Conrad,” Sir Stefan said, “your liege lord bid you attend him and you did not! I call you coward!”
There had long been bad blood between Sir Conrad and Sir Stefan. Sir Conrad stared at him for a moment, then shook his head.
“My liege lord asked for help and I gave him help! I got him and the rest of you fools out of the stupid predicament you’d gotten yourselves into. The first rule of safety is that you never touch a piece of moving machinery!”
“That’s enough, gentles,” Count Lambert said. “Sir Conrad, we thank you for your timely aid.”
“Well! That worked up an appetite! Shall we retire to dinner?”
FROM THE DIARY OF CONRAD SCHWARTZ
On returning to Cieszyn, I continued the work of getting my expedition ready.
I wanted seasoned hickory for the handles of the tools, but I didn’t get it. Seasoned wood didn't exist and the idea of using old wood struck the carpenters as being absurd. When they needed wood, they went out and cut down a tree. That's the way that it had always been done and if I wanted it any different, I could wait five years for the wood to season.
You couldn’t just buy a wheelbarrow. Nobody had ever heard of a wheelbarrow. You had to design a wheelbarrow and design all the metal parts in a wheelbarrow. Then you had to contract out the metal work, check all the work when it finally got done, and generally reject half of it because the blacksmith had ignored your drawings and instructions. Then you had to get the parts over to the brass works for heattreating, and once that was done you had to get them to the carpenters who by that time had forgotten what you wanted in the first place.
And once completed, once they got it right, they’d stand around and ask why you wanted such a silly thing in the first place.
I tell you, if the workers hadn’t needed work so badly that they were starving, I wouldn't have gotten anything done at all. But the combination of money and hunger is a powerful incentive.
As it was, I ended up spending a quarter of my considerable wealth on a few tons of hand tools.
Then there was the problem of hiring the men who would use the tools to build my facilities at Three Walls,
I One of the carpenters, Yashoo, could read and write and was good at following instructions. Furthermore, he was about the only one who picked up reading technical drawings without difficulty. I made him my carpentry foreman and together we picked out his crew.
Many of these people were his close friends and relatives and I suppose that this was nepotism, but in a small medieval city, everybody in a given trade knew each other and many of them were related. Had I made a no relatives rule, I don’t think that there would have been enough carpenters left to fill my table of organization.
Then there were the masons to hire, and the miners. Well, there weren’t that many miners available and I hired every one of them. All five.
Then we needed a blacksmith for repairs and a brewer and a baker and leather workers and all sorts of specialists.
I wouldn’t bargain on pay. I offered every man a penny a day plus food, take it or leave it. Every man took it.
At long last it all started to come together, but by then it was time to make my monthly visit to Okoitz.
I had asked Count Lambert about the girls. He said that they could visit, but only if they came each in the company of a knight. That way they would be a cut above the peasants, and their upper-class manners wouldn’t be so offensive. The Banki brothers were more than willing to visit Okoitz, although after that they had to get back to their estate, their summer holiday over.
So it was a two-day trip for a party of ten to Okoitz, with a stop at Sir Miesko’s. A waste of time, but when a bunch of young girls is giving you everything they've got, every night, it's hard to say no.
The mill was working just fine when we finally got there. All of the peripheral equipment wasn’t going yet, but a crew was sawing wood in the sawmill and another was pounding flax with the trip hammer. I left my sword with one of the workers, climbed up to the turret of the mill and went to a small turbine in the back.
Well, it was small only by comparison with the thirty ya
rd diameter of the main wheel. In fact, it was four yards across and was set at right angles to the big one. It was connected with reduction gearing to the turret such that if the big wheel wasn’t facing directly into the wind, the small wheel started spinning and turned the turret to face the wind's new direction. It seemed to be working perfectly.
I went into the turret and found that all the pumps were in operation. There were two sets of pumps. One pumped fresh water from a well to a tank at the top of the tower. This was used only for emergencies at present, with a fire hose at the base of the mill. Eventually, I hoped to install pipes for running water throughout the whole complex.
The second set of pumps took water from a tank below ground level up to a tank halfway up the tower. Water running down from this middle tank was working the sawmill down below. This arrangement let work go on even if the wind stopped.
There was only a gentle breeze blowing, but all of the pumps were going full blast. I had seriously underestimated the amount of torque a windmill of this size could generate. Well, better that than having overestimated it. The next model, if there was one, would have bigger pumps.
As I left the turret, I heard a delighted shriek from above. I looked up and saw Sir Wiktor, hanging upside down from the top of the highest turning blade. It seems that he had heard of Sir Vladimir’s adventures on the windmill and had to try it out himself.
In time, this became the standard thing to do for every young buck who visited Okoitz, a regular rite of passage. I had invented the ferris wheel.
Vitold was at work constructing the cloth factory, which surprised me. I’d expected him to be working at the second windmill, the one for threshing and grinding grain.
“It was Count Lambert who told me to build this factory first,” Vitold said. “You’ll have to talk to him if you want it done different.”
I found Lambert out in the fields.
“Sir Conrad, you really must learn to report to a castle’s lord as soon as you arrive. Courtesy requires it, and I saw you come in hours ago.”
The High-Tech Knight Page 6
